本文選題：金川鎳礦 + 新型膠凝材料��； 參考：《內蒙古科技大學》2015年碩士論文

【摘要】：充填采礦法不僅具有高回采率、低貧化率的顯著優勢，而且能夠有效地控制采空區地壓，防止地表沉陷；但存在充填料不足、充填成本高和采礦效益低等問題。 金川鎳礦是以埋藏深、圍巖破碎、地應力高為特點的難開采礦床。通過大量的采礦技術攻關和生產實踐，該最終選擇了下向分層膠結充填采礦法。目前主要使用的膠凝材料為水泥，充填骨料為棒磨砂，采用高濃度、高灰砂比料漿充填，其充填成本之高國內外不多見，使企業面臨巨大的經濟壓力。降低采礦成本是金川鎳礦最迫切問題。 甘肅省翁福集團每年排放大量的磷石膏廢渣。磷石膏廢渣的大量堆存，不僅占用了大量土地資源，還嚴重威脅了磷石膏堆場附近的地下水、地表水以及環境的安全。因此，利用磷石膏和廢石固體廢棄物，開發低成本和高強度的新型充填膠凝材料，不僅可以降低充填采礦成本，而且還實現固體廢棄物的資源化利用，實現綠色無廢開采，從而保護礦山環境，實現金川企業的可持續發展。 根據前期大量探索試驗，，以磷石膏、礦渣作為主要原料，以生石灰、NaOH和芒硝為復合激發劑，開發的新型膠凝材料配比大致范圍為：生石灰4%～6%，NaOH為2%～4%，芒硝1.5%～2.5%，磷石膏為30%～40%。 以棒磨砂為充填骨料，采用正交試驗與極差分析，確定了新型膠凝材料的最優配比：生石灰4%，磷石膏35%， NaOH為3%，芒硝為2%，礦渣為54%。當膠砂比1:4，濃度80%，其充填體3d、7d、28d抗壓強度分別達到2.17MPa、4.35MPa、8.97MPa，滿足金川鎳礦對充填體強度要求。根據SEM分析，揭示出新型膠凝材料的水化反應的主要產物是水化硅酸鈣凝膠（C-S-H）和鈣礬石（AFt）。 開展了新型膠凝材料棒磨砂料漿的流變特性的試驗研究。試驗結果表明，新型膠凝材料的充填料漿流變特性與水泥料漿的流變特性不存在本質上的差異。新型膠凝材料的充填料漿仍屬于賓漢體，滿足金川鎳礦對充填料漿自流輸送的流動性的要求。 利用Fluent軟件進行料漿在管道中輸送的數值模擬，模擬結果揭示了充填料漿在管道輸送過程中的流動狀態，清楚的觀察到充填料漿的速度及壓力分布情況。新型膠凝材料充填料漿在管道中呈現層流狀態，并存在流核（柱塞流），利用金川礦區現有自流充填系統，可以實現自流充填。
[Abstract]:The filling mining method not only has significant advantages of high recovery rate and low dilution rate, but also can effectively control gob ground pressure and prevent surface subsidence, but there are problems such as insufficient filling, high filling cost and low mining benefit.
Jinchuan nickel mine is in deep buried, broken wall rock, high stress characteristics of difficult mining. The mining technology research and production practice, the final choice of underhand cut-and-fill mining method. The cementitious materials are currently used as filling aggregate for cement, grinding sand, high concentration, high sand than the slurry filling, the filling in high cost and rare, so that enterprises are facing tremendous economic pressure. To reduce the cost of mining in Jinchuan nickel mine is the most urgent problem.
Gansu province Weng Fu Group annual emissions of a large amount of phosphogypsum residue. The stockpiling of phosphogypsum waste, not only takes up a lot of land resources, but also a serious threat to the nearby phosphogypsum yard of groundwater, surface water and environmental safety. Therefore, waste utilization of phosphogypsum and solid waste, the development of new filling material is low cost and high strength, can not only reduce the cost of filling, but also realize the resource utilization of solid waste, green waste free mining, so as to protect the mine environment, realize the sustainable development of enterprises in Jinchuan.
According to a large number of exploratory experiments in the early stage, with phosphogypsum and slag as main raw materials and quicklime, NaOH and mirabilite as composite activators, the proportion of new cementing materials is roughly 4%: 6% quicklime, 2% to 4% of NaOH, 1.5% to 2.5% of Glauber's salt, and 30% to 40%. of phosphogypsum.
The rod mill as filling aggregate, by analysis of orthogonal test and range to determine the optimal proportion of new cementitious material: phosphogypsum lime 4%, 35%, 3% for NaOH, 2% for 54%. mirabilite slag, when cement sand ratio 1:4, the concentration of 80%, the filling body 3D, 7d, 28d compressive strength respectively. 2.17MPa, 4.35MPa, 8.97MPa, to meet the requirements of the strength of the filling body of Jinchuan nickel mine. According to the SEM analysis, reveals the main product of the hydration reaction of new cementitious material is calcium silicate hydrate gel (C-S-H) and Ettringite (AFt).
Experiment was conducted to study the rheological properties of new cementitious material rod grinding slurry. The experimental results show that the rheological properties of slurry and the rheological properties of cement slurry is a new cementing material there is no difference in essence. Filling slurry of new cementitious material still belongs to Bingham, full of gold ore of Sichuan slurry gravity transportation liquidity requirements.
Numerical simulation of slurry in pipeline by using Fluent software, the simulation results reveal the flow state of filling slurry in pipeline, clearly observed velocity and pressure distribution of filling slurry. The new cementitious material of filling slurry in pipeline in the presentation layer flow state and flow (nuclear Zhu Sailiu), using Jinchuan mining existing gravity filling system, can achieve self filling.

【學位授予單位】：內蒙古科技大學
【學位級別】：碩士
【學位授予年份】：2015
【分類號】：TD853.34

【參考文獻】

相關期刊論文 前9條

1 王新星;沈海東;趙國平;;粉煤灰水泥混凝土材料水化機理研究[J];中國新技術新產品;2009年19期

2 楊南如;曾燕偉;;化學激發膠凝材料專題研討(連載一) 研究和開發化學激發膠凝材料的必要性和可行性(上)[J];建材發展導向;2006年01期

3 賀平;;流體流態測試裝置關鍵部件的設計改造[J];實驗室科學;2009年03期

4 周少平;劉文永;郭利杰;田家隆;;真然低成本充填膠凝材料的開發研究[J];有色金屬(礦山部分);2007年04期

5 孔祥文,王丹,隋智通;礦渣膠凝材料的活化機理及高效激發劑[J];中國資源綜合利用;2004年06期

6 劉金梅;盧忠遠;嚴云;舒朗;;低等級粉煤灰的研究現狀及進展[J];中國資源綜合利用;2008年06期

7 莫勇;;一種新型公路建設水泥[J];企業科技與發展;2009年22期

8 趙鵬凱;趙亮;景嬌燕;;高爐礦渣基充填膠凝材料的制備與應用[J];中國資源綜合利用;2013年08期

9 朱學安;;《通用硅酸鹽水泥》國家新標準內容變化、特點及實施的策劃[J];中國水泥;2007年05期

本文編號：1767007